Fresh air flow.
Moderators: User administrators, Moderators
- bigbadbob76
- Registered user
- Posts: 1733
- Joined: 07 Nov 2016, 14:41
- 80-90 Mem No: 15707
- Location: Isle of Skye
Fresh air flow.
I'm tempted to add some fresh air vents in the back of my panel van camper conversion as we get a lot of condensation back there when sleeping.
Looking at this pic-
The fresh air flow seems to be from the front grill- across below the dash-through the doors-up the B posts and along the top level with the gutters.
Can anyone confirm this and whether it then connects to the exterior vents in the D posts?
I don't have the fourth heater vent control lever so assume i always get fresh cold air through there.
If I was to fit interior vents in the back sides, up near the roof, would I get engine smells coming into the van?
Cheers.
BBB.
Looking at this pic-
The fresh air flow seems to be from the front grill- across below the dash-through the doors-up the B posts and along the top level with the gutters.
Can anyone confirm this and whether it then connects to the exterior vents in the D posts?
I don't have the fourth heater vent control lever so assume i always get fresh cold air through there.
If I was to fit interior vents in the back sides, up near the roof, would I get engine smells coming into the van?
Cheers.
BBB.
'86 1.9 DG, 4 spd, tintop, camper conversion.
Split case club member.
Split case club member.
-
- Registered user
- Posts: 427
- Joined: 28 Mar 2017, 10:03
- 80-90 Mem No: 15882
- Location: Warwick
Re: Fresh air flow.
Hello don't know if this link will help at all but I was trying to do a bit of research for you and stumbled across this
http://www.gowesty.com/tech-article-details.php?id=83" onclick="window.open(this.href);return false; I think you may have engine smells if you use the back vents the warm air rises and often after a drive you can small it as you walk past the vents so you may get some smells in the van unless you could close the vents when you wanted sorry if this isn't no help at all but when we first got our van I was reading the Haynes manual about the heating system also some good information and diagramed in there
http://www.gowesty.com/tech-article-details.php?id=83" onclick="window.open(this.href);return false; I think you may have engine smells if you use the back vents the warm air rises and often after a drive you can small it as you walk past the vents so you may get some smells in the van unless you could close the vents when you wanted sorry if this isn't no help at all but when we first got our van I was reading the Haynes manual about the heating system also some good information and diagramed in there
1984 1.9 dg petrol westfalia joker
Re: Fresh air flow.
Why would you get an engine smell ? The vents use air from the front of the van , the air ducts up near the roof aren't connected to the engine bay. The early Aircooled engine van could produce an engine smell from the heat exchangers into the van if there was oil dripping onto the exchangers or if the connections were loose.
1992 red lle 2.2 subaru 1990 rhd caravelle 2.2 subaru 1986 california import vanagon
-
- Registered user
- Posts: 427
- Joined: 28 Mar 2017, 10:03
- 80-90 Mem No: 15882
- Location: Warwick
Re: Fresh air flow.
Yeah just been looking at the diagrames online you are right you would not get an engine smell as multisi rightly said unless you have an air cooled with a heat exchanger but with a water cooled you will have no problem
1984 1.9 dg petrol westfalia joker
-
- Registered user
- Posts: 160
- Joined: 12 Apr 2008, 16:29
- 80-90 Mem No: 0
- Location: Bridgend, Wales
Re: Fresh air flow.
I think the 4th heater lever opens a flap in the bottom of the heater box to divert air into the front cross beam, and from there through the door beams, up the b posts and into the top rear vents.
With no 4th lever, the air won't get in to that part of the system.
Also, those vents are in no way attached to the rear engine vents.
Dave
With no 4th lever, the air won't get in to that part of the system.
Also, those vents are in no way attached to the rear engine vents.
Dave
- bigbadbob76
- Registered user
- Posts: 1733
- Joined: 07 Nov 2016, 14:41
- 80-90 Mem No: 15707
- Location: Isle of Skye
Re: Fresh air flow.
Thanks everyone.
Your confirmation that "the air ducts up near the roof aren't connected to the engine bay" and variations on that theme is re-assuring.
So I should be able to fit vents above the rear side windows.
Not having the 4th lever... I'm hoping i'll still get fresh air up there just not hot air from the heater core.
I'll check if I get any flow from the door vents next time I'm out, I always leave them shut so have never noticed if there's any fresh air coming out.
Although looking at the go-westy link it looks like these are air exits not inlets. hmmm.... interesting link Sarahandthebear.
Your confirmation that "the air ducts up near the roof aren't connected to the engine bay" and variations on that theme is re-assuring.
So I should be able to fit vents above the rear side windows.
Not having the 4th lever... I'm hoping i'll still get fresh air up there just not hot air from the heater core.
I'll check if I get any flow from the door vents next time I'm out, I always leave them shut so have never noticed if there's any fresh air coming out.
Although looking at the go-westy link it looks like these are air exits not inlets. hmmm.... interesting link Sarahandthebear.
'86 1.9 DG, 4 spd, tintop, camper conversion.
Split case club member.
Split case club member.
Re: Fresh air flow.
Sounds like you need a square motorhome roof vent on the actual roof, the little air duct vents aren't going to get rid of the condensation. I have an old fiamma vent if you go down that route.
1992 red lle 2.2 subaru 1990 rhd caravelle 2.2 subaru 1986 california import vanagon
- bigbadbob76
- Registered user
- Posts: 1733
- Joined: 07 Nov 2016, 14:41
- 80-90 Mem No: 15707
- Location: Isle of Skye
Re: Fresh air flow.
Thanks for the offer Multisi.
That would definitely give me the best ventilation but I really don't want to cut holes in my roof.
It's a virgin unmolested tin-top and I don't want to violate it.
I could maybe run some ducting up the D pillars and put vents in there as long as the ducting draws from somewhere away from the engine.
Vents in the tailgate would be an option too but would probably look crap.
An opening tailgate window would be a nice option. has anyone seen it done?
That would definitely give me the best ventilation but I really don't want to cut holes in my roof.
It's a virgin unmolested tin-top and I don't want to violate it.
I could maybe run some ducting up the D pillars and put vents in there as long as the ducting draws from somewhere away from the engine.
Vents in the tailgate would be an option too but would probably look crap.
An opening tailgate window would be a nice option. has anyone seen it done?
'86 1.9 DG, 4 spd, tintop, camper conversion.
Split case club member.
Split case club member.
Re: Fresh air flow.
You need to get some windows that open, looking at photos of your van with fixed windows and no roof vents I'm not surprised it gets a bit sweaty in there !
1992 red lle 2.2 subaru 1990 rhd caravelle 2.2 subaru 1986 california import vanagon
- itchyfeet
- Registered user
- Posts: 12427
- Joined: 23 Jul 2007, 17:24
- 80-90 Mem No: 12733
- Location: South Hampshire
Re: Fresh air flow.
Condensation ...yeh yeh....Ffffffffffffffrrrrtt.
- Mocki
- Membership Admin
- Posts: 16982
- Joined: 29 Sep 2005, 09:27
- 80-90 Mem No: 428
- Location: Mansfield Notts
- Contact:
Re: Fresh air flow.
i have those upper vents in my camper ( ex caravelle gl) they only provide cold air, and only when the van is moving
and unless you are parked facing a brisk wind nothing comes out other wise when staionary.
you dont need the 4th control though i dont think, as the vents in the bottom of the doors work all the time , but you will need the ducting and seals for the "B" pillar and roof
and unless you are parked facing a brisk wind nothing comes out other wise when staionary.
you dont need the 4th control though i dont think, as the vents in the bottom of the doors work all the time , but you will need the ducting and seals for the "B" pillar and roof
Steve
tel / txt O7947-137911
________________
1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Caravelle TS TinTop Camper
tel / txt O7947-137911
________________
1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Caravelle TS TinTop Camper
-
- Registered user
- Posts: 798
- Joined: 15 Oct 2006, 11:19
- 80-90 Mem No: 5533
- Location: rambler de oria, near albox,almeria,spain
Re: Fresh air flow.
You need to fit an extractor fan/tailgate lock open thingy...
Would be nice if the heater motor could be made to suck instead of blow!
Would be nice if the heater motor could be made to suck instead of blow!
I dont think, so I'm not[do I exist?]
1992 1600td [ jx ] syncro panel van[leisuredrive camper ]
1992 1600td [ jx ] syncro panel van[leisuredrive camper ]
- marlinowner
- Registered user
- Posts: 1530
- Joined: 28 Jan 2014, 12:02
- 80-90 Mem No: 13646
- Location: Scottish Borders
Re: Fresh air flow.
As above
https://www.brickwerks.co.uk/tailgate-stand-off-t3.html" onclick="window.open(this.href);return false;
https://www.brickwerks.co.uk/tailgate-stand-off-t3.html" onclick="window.open(this.href);return false;
1993 SA VW T25/T3 2.5i Microbus/homebrew camper
1981/1968 Marlin Kitcar TR6 Engine
1981/1968 Marlin Kitcar TR6 Engine
-
- Registered user
- Posts: 1938
- Joined: 29 Sep 2012, 12:00
- 80-90 Mem No: 11783
- Location: s. cheshire
Re: Fresh air flow.
We had the thermal window covers in the previous van which helped to cut down the condensation. Just used them on the rear and side windows.
Don't have much of a problem in current van as have a roof vent and wind deflectors so can leave windows open a bit.
Don't have much of a problem in current van as have a roof vent and wind deflectors so can leave windows open a bit.
1.9td AAZ
T25 - an adventure before dementia
T25 - an adventure before dementia
- bigbadbob76
- Registered user
- Posts: 1733
- Joined: 07 Nov 2016, 14:41
- 80-90 Mem No: 15707
- Location: Isle of Skye
Re: Fresh air flow.
itchyfeet wrote:Condensation ...yeh yeh....Ffffffffffffffrrrrtt.
It was the dog.
We have wind deflectors on the front so can leave them open a bit and a sliding window over the sink so can do the same there but really want some small vents somewhere at the back that we can cover with fine mesh to keep midgies out and not get lashing rain in.
Maybe a short ducted vent from inner skin to the top of the exterior vents.
Propping the tailgate would be a bit too much ventilation methinks, good suggestion though.
Cheers for the heads up on the vents Mocki.
'86 1.9 DG, 4 spd, tintop, camper conversion.
Split case club member.
Split case club member.