Split charge system x

The Tardis factor (interiors, awnings, roofs etc)

Moderators: User administrators, Moderators

Post Reply
scarycamper
Registered user
Posts: 22
Joined: 12 Mar 2014, 14:41
80-90 Mem No: 5888
Location: Manchester

Split charge system x

Post by scarycamper »

Hi all, I've recently bought my komet high top and was told it has a split charge system in it, is there a switch to turn it on or is always on? My water pump works and the lights haven't tried the fridge yet but the electric heater only works when on hook up! Basic I have no clue about it and google is just sending me to shops to purchase one!!
Thanks in advance

Highroller
Registered user
Posts: 219
Joined: 06 Sep 2013, 18:58
80-90 Mem No: 12833
Location: East Lothian

Re: Split charge system x

Post by Highroller »

The split charge system will charge the batteries (Starter and Leisure Battery) when the engine is running and the batteries are in good condition. Ideally you don't want the fridge running off the battery as it will flatten it in a matter of a couple of hours. In some cases fridges are wired up to run on 12 volts when the engine is running but cut off once stopped. If it is a 3 way fridge then gas or hook up would be the preferred option once parked up.
1991 2.1 WBX Devon microbus twinslider hightop

User avatar
Mocki
Membership Admin
Posts: 16957
Joined: 29 Sep 2005, 09:27
80-90 Mem No: 428
Location: Mansfield Notts
Contact:

Re: Split charge system x

Post by Mocki »

Hi
We actually have no way of knowing if you have a split charge or not , many things have happened to these vans in the 25+ years since they were first owned !

However there are a couple of very simple tests you can do to find out

1. Switch your water pump on and disconnect the neg connection of your leisure battery - if the pump stops, it works from the leisure battery
Now if it is working from the leisure battery, and has stopped , start your engine , if the pump starts again, you have a split charger . Now I guess, look for a switch which doesn't do anything else, and see if it makes the pump stop whilst the engine is running .

As for heater only working on hook up, if it's a mains heater, it cannot work unless you are connected to the mains .
Steve
tel / txt O7947-137911
👀
________________

1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Caravelle TS TinTop Camper 
 

User avatar
nicq
Registered user
Posts: 1185
Joined: 24 Sep 2011, 19:03
80-90 Mem No: 10290
Location: Cranleigh Surrey

Re: Split charge system x

Post by nicq »

Mocki wrote: As for heater only working on hook up, if it's a mains heater, it cannot work unless you are connected to the mains .
Or it could be it is running off of a mains charger for the leisure battery that may not be fitted, there may be a changeover switch from leisure to van bat for the rest.
You will have to have a good rummage.
2.1 Twin slider

scarycamper
Registered user
Posts: 22
Joined: 12 Mar 2014, 14:41
80-90 Mem No: 5888
Location: Manchester

Re: Split charge system x

Post by scarycamper »

The water pump doesn't switch off when you take the negative off! So I guess it's not got a split charge?

User avatar
Mocki
Membership Admin
Posts: 16957
Joined: 29 Sep 2005, 09:27
80-90 Mem No: 428
Location: Mansfield Notts
Contact:

Re: Split charge system x

Post by Mocki »

Then that means your water pump,is not working off the leisure battery , if you did the test in the order I said !
What is wired to the leisure battery then ? Just lights ?
Or do you have a control panel with a "car" / "van" switch ? It needs to be on "van" to do the test I suspect .
Steve
tel / txt O7947-137911
👀
________________

1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Caravelle TS TinTop Camper 
 

scarycamper
Registered user
Posts: 22
Joined: 12 Mar 2014, 14:41
80-90 Mem No: 5888
Location: Manchester

Re: Split charge system x

Post by scarycamper »

Opened up both battery covers and main battery has a black square shaped box squeezed in next to it, only wording I can make out is 12v, it's attached to the side of the battery compartment, the leisure has a red wire running out under the carpet, the red wire from the that runs out on the other battery comes out of the small box? ! Does that help work it out? Thanks
Last edited by scarycamper on 08 May 2017, 19:16, edited 1 time in total.

scarycamper
Registered user
Posts: 22
Joined: 12 Mar 2014, 14:41
80-90 Mem No: 5888
Location: Manchester

Re: Split charge system x

Post by scarycamper »

I can take pics but don't know how to post them on here!

scarycamper
Registered user
Posts: 22
Joined: 12 Mar 2014, 14:41
80-90 Mem No: 5888
Location: Manchester

Re: Split charge system x

Post by scarycamper »

Ok small box says voltage sensitivity reading, 12v 140 amp!! Not sure what any of that means?

User avatar
Oldiebut goodie
Registered user
Posts: 7265
Joined: 18 Apr 2008, 01:19
80-90 Mem No: 11135
Location: Eastern Angle

Re: Split charge system x

Post by Oldiebut goodie »

voltage sensitive RELAY I should think - that will be your split charge relay.
1.6D 2019 VW T-Cross
200hp VW T6
1̶Y̶ ̶1̶9̶8̶7̶ ̶H̶i̶-̶t̶o̶p̶ ̶C̶a̶r̶a̶v̶e̶l̶l̶e̶
5̶0̶8̶d̶ ̶M̶e̶r̶c̶

Sir Brixalot
Registered user
Posts: 4569
Joined: 15 Oct 2010, 21:55
80-90 Mem No: 8927
Location: London

Re: Split charge system x

Post by Sir Brixalot »

Can't be definite without a pic but certainly sounds like a split charge relay. Take a reading on your leisure battery with the engine running, should be 13.8+
Honorary "Dave" 

 

scarycamper
Registered user
Posts: 22
Joined: 12 Mar 2014, 14:41
80-90 Mem No: 5888
Location: Manchester

Re: Split charge system x

Post by scarycamper »

Thanks for that, how do I take a reading off my leisure battery? Sorry

scarycamper
Registered user
Posts: 22
Joined: 12 Mar 2014, 14:41
80-90 Mem No: 5888
Location: Manchester

Re: Split charge system x

Post by scarycamper »

Mocki wrote:Then that means your water pump,is not working off the leisure battery , if you did the test in the order I said !
What is wired to the leisure battery then ? Just lights ?
Or do you have a control panel with a "car" / "van" switch ? It needs to be on "van" to do the test I suspect .
I haven't found a control panel anywhere, any clues as to where it would be?

User avatar
Mocki
Membership Admin
Posts: 16957
Joined: 29 Sep 2005, 09:27
80-90 Mem No: 428
Location: Mansfield Notts
Contact:

Re: Split charge system x

Post by Mocki »

it will be obvious if you have one, they dont hide them!!
you need to buy a multimeter if you want to investigate further i think
Steve
tel / txt O7947-137911
👀
________________

1989 2.1LpgWBX HiTop Leisuredrive Camper
1988 2.1 Caravelle TS TinTop Camper 
 

scarycamper
Registered user
Posts: 22
Joined: 12 Mar 2014, 14:41
80-90 Mem No: 5888
Location: Manchester

Re: Split charge system x

Post by scarycamper »

Thanks for all your help

Post Reply