Main Battery Discharging? '88 Autosleeper High Top

An alchemy of sparks, copper wire and earth

Moderators: User administrators, Moderators

Post Reply
triumph2.5pi
Registered user
Posts: 108
Joined: 14 Dec 2013, 00:35
80-90 Mem No: 0
Location: Hastings, East Sussex

Main Battery Discharging? '88 Autosleeper High Top

Post by triumph2.5pi »

Hi all

I wondered if someone might be able to advise of an ongoing problem I've been having? Over a year ago I noticed that the main battery would discharge from fully charged to not having enough power to be able to crank over the starter motor if it wasn't driven for about a week. Here's a summary of what I've done over the last year or so:

-Fitted a new battery.
- Took it to my local trusted T25 specialist who said battery and charging system was fine, although the stereo was drawing a very small amount of power even when off. So fitted an on/off isolator switch for the stereo to the dash.
-Took it to a specialist auto electrician who confirmed nothing wrong and nothing drawing power when not running.
- Took it back to T25 specialist who confirmed nothing they could see was wrong.
- Fitted a solar panel to keep the battery topped up. This appeared to keep the battery topped up over the summer months but now the days are shorter (and maybe it's colder?), I'm having the same issue again.

I've tested the battery voltage regularly and here an example of the readings after a full, slow 8+ hour mains charge:

12.99v fully charged before fitting (after a few hours 'rest' after charging). 12.93v fitted to van. 13.73v running. 13.10v engine off immediately after a run.

Day 1 12.93v
Day 10 12.15v :-(

The van does have a tracker - one of the cheap generic ones. Could that be drawing that much power that quickly? That's the only thing I can think of, although as started above the van's been tested for anything drawing power when off and there doesn't appear to be anything....

I'm a complete layman and Ive run out of ideas now! Any help/pointers would be much appreciated! Thanks :-)
1988 Autosleeper High Top
2.1DJ (Pierburg carb)
AAP 5 Speed, 711 Shifter

User avatar
bigherb
Registered user
Posts: 2579
Joined: 27 Mar 2008, 13:50
80-90 Mem No: 5789
Location: West Kent

Re: Main Battery Discharging? '88 Autosleeper High Top

Post by bigherb »

Actually your charging voltage is marginal, the battery may not be charging fully when you are driving. Minimum should be 13.8V, ideally it should be 14.2V-14.4V dropping the more load you switch on to 13.8V.
If all the wiring connections are clean and tight change the alternator voltage regulator for higher voltage 14.2V or 14.4V one.
1982 Camper 1970 1500 Beetle Various Skoda's, Ariel Arrow

triumph2.5pi
Registered user
Posts: 108
Joined: 14 Dec 2013, 00:35
80-90 Mem No: 0
Location: Hastings, East Sussex

Re: Main Battery Discharging? '88 Autosleeper High Top

Post by triumph2.5pi »

Thanks a lot, appreciate the advice :-)
1988 Autosleeper High Top
2.1DJ (Pierburg carb)
AAP 5 Speed, 711 Shifter

User avatar
a1winchester
Registered user
Posts: 1084
Joined: 30 Jul 2009, 22:09
80-90 Mem No: 7187
Location: Spilsby Lincolnshire

Re: Main Battery Discharging? '88 Autosleeper High Top

Post by a1winchester »

I had this problem - Solved by doing 2 things.
1) Fitted a battery isolator switch - the clock also drains the battery as well as the stereo.
2) Bought a starter pack in case of flat battery. I haven't had to use it yet (touch wood) since getting the isolator switch and starter pack.

Downside is the clock is never the right time.
Upside is it's an extra security measure against theft.

Oh, and check the alternator belt is tensioned correctly. It can slip without you knowing in a rear engined van as you don't hear it slipping.
1990 Autosleeper Trident. Water cooled 1.9L DG + 4 speed manual box

triumph2.5pi
Registered user
Posts: 108
Joined: 14 Dec 2013, 00:35
80-90 Mem No: 0
Location: Hastings, East Sussex

Re: Main Battery Discharging? '88 Autosleeper High Top

Post by triumph2.5pi »

Thanks that sound like a good idea. Where is your battery isolator switch located?
1988 Autosleeper High Top
2.1DJ (Pierburg carb)
AAP 5 Speed, 711 Shifter

User avatar
a1winchester
Registered user
Posts: 1084
Joined: 30 Jul 2009, 22:09
80-90 Mem No: 7187
Location: Spilsby Lincolnshire

Re: Main Battery Discharging? '88 Autosleeper High Top

Post by a1winchester »

triumph2.5pi wrote:Thanks that sound like a good idea. Where is your battery isolator switch located?
You have pm. The secret isolator switch is located in the....
1990 Autosleeper Trident. Water cooled 1.9L DG + 4 speed manual box

User avatar
CovKid
Trader
Posts: 8409
Joined: 30 Apr 2006, 13:19
80-90 Mem No: 3529
Location: Ralph - Coventry (Retired)
Contact:

Re: Main Battery Discharging? '88 Autosleeper High Top

Post by CovKid »

Yeah, its easy to find, seen it several times. Its in the....
Roller paint your camper at home: http://roller.epizy.com/55554/" onclick="window.open(this.href);return false; for MP4 download.

User avatar
sarran1955
Registered user
Posts: 1440
Joined: 11 Mar 2009, 18:51
80-90 Mem No: 6754
Location: 6, les Hauts de Sarran 19800, Sarran ,Limousin ,FRANCE

Re: Main Battery Discharging? '88 Autosleeper High Top

Post by sarran1955 »

Hello,

My 100 amp isolator switch is clearly visible, next to the 220v cut off , the fire extinguisher, and the first aid kit..

as you open the sliding door..

Cordialement,

:ok
Image

Sir Brixalot
Registered user
Posts: 4569
Joined: 15 Oct 2010, 21:55
80-90 Mem No: 8927
Location: London

Re: Main Battery Discharging? '88 Autosleeper High Top

Post by Sir Brixalot »

Had a similar problem. To cut a Long story short the wire inside the lug on the alternator had perished and charging was sporadic
Honorary "Dave" 

 

Post Reply