gear linkage - play - at gearbox end
by
Jim San »
29 Jul 2022, 15:06
(Diesel Syncro)
How much play should there be in the gear selection rod (long section) going through the T-section into the box? At a guess mine has...
0 Replies
961 Views
Last post by Jim San
29 Jul 2022, 15:06
Coolant Parts...
Replies: 7
by
herman_t25 »
25 Jul 2022, 09:24
Morning All,
sorry in advance for a question on coolant/cooling!
The other week my beloved t3 decided to dump all of its coolant on the carpark at...
7 Replies
421 Views
Last post by herman_t25
27 Jul 2022, 09:57
Gear Linkage - 4 Speed Air Cooled
Replies: 2
by
sburch »
26 Jul 2022, 19:38
Hi Folks,
Havnt posted in here for a while as Van has been blessfully free of troubles...until now that is :-)
Gear changes up until now have...
2 Replies
175 Views
Last post by multisi
27 Jul 2022, 08:42
0 Replies
944 Views
Last post by fungusface
26 Jul 2022, 20:52
Going to Cornwall...
Replies: 7
by
ozman »
06 Jul 2022, 06:18
Hi All,
I'm going to Cornwall next year. The 1.9 wasserboxer plus auto will get a good run... But concerned about reliability so going to break our...
7 Replies
456 Views
Last post by pkrboo
26 Jul 2022, 20:29
Coolant hoses.
Replies: 9
by
escovedo »
25 Jul 2022, 10:41
Can anyone advise on what coolant hose mods are required
when replacing the injection system on my 2.1 DJ engine van
with the Pierburg carb manifold...
9 Replies
253 Views
Last post by escovedo
25 Jul 2022, 18:37
Leaky Head Nut. Options?
Replies: 13
by
maxstu »
24 Jun 2022, 21:36
Number 5 nut on cylinder No. 1 has a slight weep. Nothing staining the driveway. But the coolant needs topping up with half a pint every 500 miles or...
13 Replies
583 Views
Last post by maxstu
25 Jul 2022, 16:25
DJ heads on a DG engine
Replies: 3
by
adsnape »
24 Jul 2022, 17:04
Is this possible? I have an option on a DG block and a set of DJ heads, I was thinking of marrying them up? ALL the part numbers seem to tally, is it...
3 Replies
197 Views
Last post by Robsey
25 Jul 2022, 10:29
Advice needed - new engine
Replies: 5
by
karlyau »
14 Jul 2022, 21:41
Hi, I need some guidance … 6 years after selling my Holdsworth, I recently paid 9k for a t25 Autosleeper 1.6 jtd.
On the way home it overheated big...
5 Replies
517 Views
Last post by kernewek
24 Jul 2022, 23:08
Metal in the injectors
Replies: 16
by
Bryce »
31 May 2022, 13:55
Me again, had the van towed to garage for a knock in engine and found injector was stuck open.
Garage have just rang to say it happened again on...
16 Replies
679 Views
Last post by Bryce
23 Jul 2022, 23:11
Oil pressure relief
Replies: 3
by
Elsaetka »
21 Jul 2022, 06:45
Hi
Hope someone can help me out here, my oil pressure relief valve seal started leaking (1.9 1990 water-cooled). I changed the seal and spring...
3 Replies
266 Views
Last post by DoubleOSeven
23 Jul 2022, 12:13
5 Replies
359 Views
Last post by ianders
22 Jul 2022, 18:47
Telescopic pushrod tube dilema
Replies: 3
by
aec »
20 Jul 2022, 18:47
I finally got round to sorting my pushrod tubes that have been leaking oil since soon after I got the van (14 years back). A while back I bought a...
3 Replies
238 Views
Last post by aec
22 Jul 2022, 16:19
LT40 Turbo valve and pump timing
Replies: 5
by
jimsvwlt40 »
20 Jul 2022, 10:39
I have a normally asperated 6 cyl diesel in my LT40 which i am converting to rally service barge and motor home , so i bought a turbo intercooler...
5 Replies
219 Views
Last post by hubcap61
22 Jul 2022, 09:33
4 Replies
250 Views
Last post by Robsey
21 Jul 2022, 22:16
ATF cooler?
Replies: 9
by
Autodaisy »
20 Jul 2022, 18:50
I have a 1989 petrol auto campervan. Had a high pitched whine coming from the gearbox & it’s been caused by failure of the ATF cooler, the gearbox...
9 Replies
267 Views
Last post by Autodaisy
21 Jul 2022, 15:30
Carb issue??
Replies: 3
by
mike9009 »
16 Jul 2022, 14:16
Not sure if this is an issue or not....and I just need to stop worrying
I have a 2.0L CU engine with twin Weber carbs (ICT34, from memory). It runs...
3 Replies
327 Views
Last post by mike9009
20 Jul 2022, 18:23
wear to distributor
Replies: 22
by
Mona »
21 Jun 2022, 17:18
Hi All,
I'm in the process of replacing my distributor, but it isn't gripping the drive properly. It is fine without the clamp, but when the clamp...
22 Replies
902 Views
Last post by Mona
20 Jul 2022, 18:08
Jx air intake ducting
Replies: 4
by
pierce »
18 Jul 2022, 18:06
I have been running my van without any of the clean air ducting and snorkel connected to my air filter, it’s never seem to have done any harm, but...
4 Replies
256 Views
Last post by pierce
18 Jul 2022, 19:50
Fuel problem
Replies: 9
by
JeffRoo »
11 Jul 2022, 21:14
Hi all, need a little guidance if possible. 1.9DG mechanical fuel pump as standard.
The problem: when the engine is hot and I turn it off it will...
9 Replies
399 Views
Last post by JeffRoo
17 Jul 2022, 21:41
Geerbox electric disconnection Q
Replies: 3
by
Slaydog »
15 Jul 2022, 21:43
Could someone kindly advise what this split wire is stopping working and the consequence? :-)
Apologies for the photo quality
Sent from my...
3 Replies
173 Views
Last post by Robsey
16 Jul 2022, 14:52
8 Replies
434 Views
Last post by Slaydog
16 Jul 2022, 13:01
6 Replies
537 Views
Last post by silverbullet
14 Jul 2022, 06:19
Oil change??? T3 2LTR
Replies: 9
by
Swissy0 »
07 Jul 2022, 22:54
Hi any help please ,what is the correct length for my t3 1980 2l air-cooled engines dip stick I've just done an oil change book says 3.5 litres...
9 Replies
462 Views
Last post by Rosie n' Jim
14 Jul 2022, 05:53
Weber dgav carb
Replies: 1
by
Dukey »
13 Jul 2022, 18:30
Hi has anyone converted to a Weber dgav carb on their 1.9 dg ?. I have been told it would be a good move but thought I would ask first.
1 Replies
119 Views
Last post by silverbullet
13 Jul 2022, 21:30
Carb refurb 1.9 dg
Replies: 6
by
Dukey »
28 May 2022, 18:35
I'm looking to get my pierberg carb refurbed on my 1.9 dg and wondered if anyone knows where I can get this done. I'm located in Hertfordshire.
Any...
6 Replies
529 Views
Last post by Cobra88
13 Jul 2022, 20:17
PAS Rack Rebuild Kit
Replies: 4
by
Splurt »
09 Jul 2022, 13:15
Does anyone have any experience with getting a power steering rack rebuilt?
Mine is leaking so the plan is to remove it and have it reconditioned. I...
4 Replies
367 Views
Last post by Simon Baxter
11 Jul 2022, 14:19
Tiny pin in distributor / hall sender
Replies: 3
by
Slaydog »
08 Jul 2022, 18:27
Anyone know where I can get a replacement pin that shot out when dismantling and can’t be found
It was a solid small one and the replacement hall...
3 Replies
221 Views
Last post by Slaydog
10 Jul 2022, 20:55
1.9DG waterjacket leak
Replies: 4
by
jamie.smith »
03 Apr 2022, 15:22
Hi, aware that this has been covered but just wanted to seek some opinions before I resign myself to a 4k+ cost of a new engine.
I have a leak at...
4 Replies
417 Views
Last post by jamie.smith
09 Jul 2022, 08:50
Rear Brake Drum overheating - just 1
Replies: 4
by
peteinnit »
05 Jul 2022, 17:20
Hi all,
Wondering if anyone has experienced the following, it might be a little long winded......
So, preparing for a road trip after 2 years of...
4 Replies
303 Views
Last post by peteinnit
07 Jul 2022, 19:58
8 Replies
369 Views
Last post by Shinnster
07 Jul 2022, 13:21
1 Replies
159 Views
Last post by toolsntat
06 Jul 2022, 20:56
7 Replies
247 Views
Last post by Aidan
06 Jul 2022, 15:26
Diesel leak from tank
Replies: 5
by
Al Housman »
12 Jun 2022, 09:50
Doka syncro LHD. I've noticed a small leak which is dripping down on the left hand side so opposite the fuel filler.
Is it possible that a seepage...
5 Replies
323 Views
Last post by Al Housman
06 Jul 2022, 08:20
Air Intake Boot......Newbie
Replies: 14
by
GrahamL »
03 Nov 2014, 22:50
Hi,
Just noticed open end of the air intake boot to my engine ( diesel ) just lays in a void behind the near side rear light cluster......is this...
14 Replies
11203 Views
Last post by Aidan
06 Jul 2022, 06:54
T25 2.1 DJ running issue.
Replies: 4
by
escovedo »
04 Jul 2022, 05:45
My recently purchased T25 DJ engine van has developed a a running
problem, the van starts easily and idles perfectly at 900 rpm, revs freely
when...
4 Replies
235 Views
Last post by escovedo
05 Jul 2022, 15:19
New exhaust system
Replies: 8
by
grayzer1 »
30 Jun 2022, 18:29
Hi bit of a daft question, but just purchased a whole new exhaust system off Just Kampers and every part has a sticker saying paint needs removing...
8 Replies
601 Views
Last post by davidoft1
01 Jul 2022, 22:10
Wheel Bearing Question
Replies: 12
by
Ant-t »
15 Jun 2022, 14:25
My osf wheel bearing has failed again, it's been replaced twice in the last two years. It's grumbling and has only has slight vertical play when...
12 Replies
735 Views
Last post by Stesaw
01 Jul 2022, 17:50
Can someone direct me to
Replies: 3
by
dandaz »
28 Jun 2022, 20:02
The putting ethenol petrol in a dg engine please..
I promise I have spent 15 minutes searching
Sent from my ART-L29 using Tapatalk
3 Replies
326 Views
Last post by dandaz
30 Jun 2022, 17:01
4 Replies
195 Views
Last post by LeonardGW
30 Jun 2022, 12:23
Old DJ injection conversion
Replies: 25
by
Crewcab21 »
13 Mar 2021, 11:46
Hello
Got a few parts available to convert the old DJ and MV injection system over to a modern aftermarket ECU
with new readily available sensors...
25 Replies
3096 Views
Last post by Crewcab21
28 Jun 2022, 20:20
Fuel injecting a DG engine.
Replies: 13
by
bigbadbob76 »
21 Sep 2017, 13:45
Having successfully fuel injected a citroen 2cv6 engine I got to thinking I could do the same for my DG engine.
I'm after fuel economy over...
13 Replies
2670 Views
Last post by Crewcab21
28 Jun 2022, 20:07
1.9dg starting problem
Replies: 7
by
lukeskywalker945 »
27 Jun 2022, 12:12
Hi everyone.
My 1989 1.9dg has been sat for a while while I’ve been having bodywork done (approx 6 months)
We fully charged the battery and tried...
7 Replies
363 Views
Last post by tandemsandy
27 Jun 2022, 20:56
1 Replies
175 Views
Last post by DoubleOSeven
27 Jun 2022, 17:31
Which transmission mount?
Replies: 6
by
Robsey »
26 Jun 2022, 14:05
Hi all
Silly question time.
When dropping my gearbox out from the van, I noticed a huge amount of movement in the rubber of the mount at the front...
6 Replies
269 Views
Last post by Robsey
27 Jun 2022, 11:19
Rolling Roads in the South East
Replies: 6
by
AdamKeelan »
24 Jun 2022, 11:41
Hi there - apologies if the answer's already out there, but can anyone recommend a rolling road and tuning service in the South East for our T25 air...
6 Replies
310 Views
Last post by AdamKeelan
27 Jun 2022, 07:02
Position front mount gearbox to chassis
Replies: 1
by
Nasic »
26 Jun 2022, 16:32
Hello,
Because we are restorating our vanagon for a while now, i don't remember anything anymore.....
Last week i decided to mount the gearbox and...
1 Replies
141 Views
Last post by Robsey
26 Jun 2022, 21:16
Relocating fuel filter
Replies: 11
by
TONYT25T25 »
15 Jun 2022, 18:16
Eventually getting around to removing the fuel filter from the engine bay, current set up is the transparent one in the engine bay and another one...
11 Replies
589 Views
Last post by TONYT25T25
26 Jun 2022, 18:12
Oil leak: that strange rare feeling…
Replies: 6
by
adebutter »
23 Jun 2022, 23:22
Fearing the worst; as oil was dripping continuously from the centre block directly under the pushrods…
Can you imagine how nice it is to spend 90 min...
6 Replies
258 Views
Last post by ajsimmo
26 Jun 2022, 08:10
38 Replies
1785 Views
Last post by Robsey
25 Jun 2022, 17:22
Forum permissions
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot post attachments in this forum