CS1.6 T25 won't start..why?
by
Paul7502 »
19 Nov 2023, 17:26
Hi back again after over a year.
Its been getting more smokey over the last year or so and sometimes difficult to start.
Now it won't start at all,...
0 Replies
44068 Views
Last post by Paul7502
19 Nov 2023, 17:26
Replacing injector pipes on JX
Replies: 6
by
julieewendubbus »
05 Jan 2023, 17:37
Hi everyone
One of my injector pipes has sheared, resulting in a lot of smelly diesel being sprayed out in my engine bay. Looks like the bracket that...
6 Replies
7568 Views
Last post by Paul7502
19 Nov 2023, 17:22
4 Replies
6963 Views
Last post by bmouthboyo
16 Nov 2023, 20:33
Front wheel bearing collapsed
Replies: 1
by
Burrich »
15 Nov 2023, 10:32
Does anyone know of a garage in the St Albans area that can replace a front wheel bearing. T25 1.9 auto 1987.
Broke down on M25 awaiting breakdown!
1 Replies
6325 Views
Last post by Oldiebut goodie
15 Nov 2023, 11:35
0 Replies
43325 Views
Last post by Magic01
10 Nov 2023, 18:13
27 Replies
22213 Views
Last post by maxstu
10 Nov 2023, 17:16
FAILED on emissions
Replies: 3
by
Advanture Magazine »
07 Nov 2023, 12:50
Just had my ITV (MOT) in Spain and failed the emissions test. Not quite sure where to start with this, other than visiting a garage. But what would...
3 Replies
6611 Views
Last post by ZsZ
07 Nov 2023, 16:14
T25 vacuum pipe with check valve
Replies: 7
by
Burrich »
04 Nov 2023, 13:22
Has anyone replaced one of these? Apparently they are not available so I am looking for an alternative method to replace it.
7 Replies
7759 Views
Last post by davidoft1
04 Nov 2023, 23:37
what is this hook for ??
Replies: 15
by
Rich75 »
18 Sep 2023, 19:30
Hi, so, as the title implies.. does anyone know what this hook is for.. its just hanging there flapping about which doesn't seem right.. pic taken...
15 Replies
14934 Views
Last post by trundletruc
04 Nov 2023, 12:30
Fuel explosion in carb
Replies: 3
by
matthew13 »
01 Nov 2023, 23:11
Good evening, got a 2 ltr cu engine petrol van and problems with the right hand carb. With rocket cover off if I accelerate you can see an explosion...
3 Replies
6714 Views
Last post by ajsimmo
03 Nov 2023, 23:14
High temp 1.9 dg
Replies: 22
by
mark »
06 Sep 2022, 20:57
Hiya
Had an issue on the way to whitby, flashing light and temp up and over 3/4 of gauge yesterday.
Had a look today.. coolant in the rad no air...
22 Replies
17833 Views
Last post by maxstu
03 Nov 2023, 22:54
JX fuel filter clamp
Replies: 5
by
Rdav1s »
27 Oct 2023, 10:32
Hi all,
Does anyone have, or know where I can get a fuel filter clamp for my 88 jx diesel syncro.
I ordered a petrol one by mistake as it looked...
5 Replies
6970 Views
Last post by ZsZ
03 Nov 2023, 07:04
stalling.
Replies: 1
by
HighgateT25 »
02 Nov 2023, 16:21
Hi All,
I bought a 1981 T25 Campervan in the summer. It wasn’t running the greatest but seemed to just be a carb issue. It just kept stalling at...
1 Replies
6199 Views
Last post by cotswoldstony
03 Nov 2023, 01:29
Engine/gearbox swap
Replies: 2
by
kentishvanman »
30 Oct 2023, 12:05
Currently run on my 1.9 water cooled and lpg when you can find a garage. No problems but did think about swapping engine and gearbox for something...
2 Replies
6462 Views
Last post by Porkscratching
30 Oct 2023, 18:26
Gearbox linkage boot?
Replies: 5
by
Shinnster »
08 Oct 2023, 14:06
Hi all,
just had the van MOT'd and was advised to change out this worn boot / gaiter that is by the gearbox.
can anyone tell me the exact name of...
5 Replies
7291 Views
Last post by ajsimmo
29 Oct 2023, 17:29
Engine stalling
Replies: 3
by
Freddievan »
08 Oct 2023, 20:24
Engine needed to be turned 2 or 3 times as the van has been stood for a few days. Once it started it sounded fine. However, half a mile down the...
3 Replies
6508 Views
Last post by JeffRoo
24 Oct 2023, 18:19
Power Steering Question
Replies: 4
by
Porkscratching »
23 Oct 2023, 15:44
Sounds like the fluid is low. Wouldn't hurt to drain what's in it and refill with fresh ATF (automatic transmission fluid) and check the pipes for...
4 Replies
6979 Views
Last post by multisi
24 Oct 2023, 08:06
2 Replies
6370 Views
Last post by Gunter98
22 Oct 2023, 15:39
Cold start cable routing
Replies: 3
by
chalkywoods »
22 Oct 2023, 12:04
The fuel pump on my AAZ fitted by previous owner has a cold start lever but it has never been hooked up. I've got all the parts but it's not obvious...
3 Replies
6610 Views
Last post by chalkywoods
22 Oct 2023, 12:47
Drive Belt treatment
Replies: 8
by
kentishvanman »
19 Oct 2023, 18:17
Have a noisy/screeching drive/fan belt. It is a new belt and tensioned 'right up'. All wheels cleaned. Only screeches for about 10/15secs after start...
8 Replies
7933 Views
Last post by ZsZ
21 Oct 2023, 06:08
Replacement pilot fuel/air jet
Replies: 10
by
Jimmucks »
13 Jun 2016, 12:48
Hi, can anyone tell me if it is possible to buy just a pilot jet for a pier burg carb. I'm not too hot on these yet and I'm struggling to find a...
10 Replies
9853 Views
Last post by Bugsted
18 Oct 2023, 20:30
5 Replies
6730 Views
Last post by mioba
18 Oct 2023, 16:25
cylinder block question
Replies: 1
by
Lio »
17 Oct 2023, 16:54
Hello everybody,
Is the cylinder block for a JX engine (1.6 turbo D) the same than for the non turbo engine ?
I just found out that my cylinder block...
1 Replies
6117 Views
Last post by davidoft1
17 Oct 2023, 21:04
CV boot replacement
Replies: 19
by
kit »
31 May 2016, 23:00
Hi I can't find anywhere on Wiki that shows CV boot replacement, does anyone know of any guide thanks?
19 Replies
14507 Views
Last post by Robsey
17 Oct 2023, 18:57
Radiator cowl
Replies: 2
by
T25Colin »
16 Sep 2023, 22:25
Back from the hols in France (after the frantic alternator change that meant we lost a night) and the van has decided to let the radiator go! For...
2 Replies
5023 Views
Last post by T25Colin
16 Oct 2023, 21:18
4 Replies
5139 Views
Last post by aec
16 Oct 2023, 17:15
coolant levels,
Replies: 5
by
syncro4us »
14 Oct 2023, 15:42
Have been running our rebuilt 2.1 engine for some time with over 2000 KM on the clock so its well run in, so this summer took it to the Pyrenees and...
5 Replies
3526 Views
Last post by Stesaw
16 Oct 2023, 13:30
Carburettor flooding
Replies: 13
by
Brenty »
14 Oct 2023, 18:40
Hi, first posting on the site. Jumped into my 1984 T25 last weekend and it was a no starter.
The carburettor was flooding- so start- then loads of...
13 Replies
3930 Views
Last post by Brenty
15 Oct 2023, 19:26
Valve Springs
Replies: 7
by
Mick.source »
01 Oct 2023, 12:07
Well i finally found the problem with my 1986 westfalia t25 jx camper, which had a rough idle and smoked under load, after removing the head i found...
7 Replies
2888 Views
Last post by lefty67
13 Oct 2023, 18:43
1 Replies
2043 Views
Last post by sarran1955
13 Oct 2023, 01:20
Clutch lever
Replies: 2
by
Rjduncanuk »
09 Oct 2023, 08:09
Hi guys, please could anyone tell me if the clutch arm is moving enough? I'm having trouble with selecting gears. The van has been stood for over 6...
2 Replies
1961 Views
Last post by Rjduncanuk
09 Oct 2023, 14:03
Brake Hydraulic failure
Replies: 10
by
garyd »
07 Oct 2023, 13:59
My son has just had a weird brake hydraulic failure on his van which we can't get to the bottom of. It is a 1990 2wd van with the 1.9 DG engine.
On...
10 Replies
2545 Views
Last post by multisi
08 Oct 2023, 14:45
Automatic Drive Shaft Seal Replacement
Replies: 1
by
maxstu »
29 Sep 2023, 08:25
Is it the same replacement procedure as manual seals?
Also, the plastic plate. Are they the same for auto and manual. I can't find any listed for...
1 Replies
1630 Views
Last post by maxstu
06 Oct 2023, 13:34
Emissions not failure
Replies: 7
by
matthew13 »
03 Oct 2023, 21:01
Hi all. 1983 2ltr cu engine petrol van. Took it for an mot today and it failed on emissions. Anyone got any tips to low the emissions?
7 Replies
1587 Views
Last post by lefty67
05 Oct 2023, 14:29
2 Replies
376 Views
Last post by lefty67
05 Oct 2023, 09:48
coolant issue
Replies: 5
by
Lio »
11 Aug 2023, 12:59
Hello,
I did some search on this forum but did not find the exact same issue that I am facing.
I have a turbo D / JX engine from 1987, and that has...
5 Replies
635 Views
Last post by Lio
03 Oct 2023, 18:15
Dellorto 36 install
Replies: 2
by
chrisc23 »
07 Sep 2023, 18:00
Hi guys I’m sort of new here although I have been sneaking around for a couple of years now and generally finding what I need from the search...
2 Replies
416 Views
Last post by PetenAli
01 Oct 2023, 19:29
Diesel Injector pump leak jx
Replies: 11
by
Cecil »
04 Sep 2023, 21:35
I have a fuel leak that is dripping off the bottom of the support bracket on the end of the injection pump just to the right of the bolt head. I have...
11 Replies
829 Views
Last post by Cecil
01 Oct 2023, 06:16
Carb rebuilders
Replies: 4
by
Elsaetka »
29 Sep 2023, 04:13
Hi
Can anyone recommend a quality / reliable Pierburg carb rebuilder for my late 1.9 DG transporter. As per forum advice I was going with Bromyard...
4 Replies
640 Views
Last post by 300CE
29 Sep 2023, 21:14
Engine number confusion
Replies: 24
by
Biggy »
15 Aug 2023, 20:10
Hi Everyone,
I need a bit of help identifying my engine. I was under the impression I had a 1.6D CS, but after trying to find the engine number to...
24 Replies
3733 Views
Last post by ZsZ
29 Sep 2023, 13:13
1 Replies
761 Views
Last post by silverbullet
29 Sep 2023, 12:49
Which Exhaust 1983 Watercooled 1.9
Replies: 3
by
makebigplans »
28 Sep 2023, 13:47
Ok, so it seems our exhaust needs some love. In fact it pretty much needs replacing due to the dreaded rust and terrible use of gun gum, however I'm...
3 Replies
363 Views
Last post by ajsimmo
28 Sep 2023, 15:04
R9 fuel hose inner lining blocking hose?
Replies: 9
by
aec »
24 Sep 2023, 12:54
After 5 years off the road and a lot of very slow DIY repairs my van (1.9DG) passed it's MOT last week. Hurrah! My joy was short lived though, on...
9 Replies
1682 Views
Last post by aec
28 Sep 2023, 10:56
Repeated Head Gasket failure
Replies: 10
by
Rich75 »
31 Jan 2023, 14:04
Hi
So, about 3 years ago I had a recon engine fitted to my 1986 1.9DG T25. It was fine and then started leaking - back to the garage that fitted the...
10 Replies
1611 Views
Last post by silverbullet
25 Sep 2023, 19:51
6 Replies
597 Views
Last post by grace72
24 Sep 2023, 14:50
What engine and carb do I have
Replies: 10
by
Raynsford5 »
19 Sep 2023, 06:23
Hi all having bought our first money pit a beautiful red and white T3/T25 i have come to a self conclusion the previous owners may have installed a...
10 Replies
851 Views
Last post by hubcap61
21 Sep 2023, 08:32
Moutning bolt on carb loose/stripped
Replies: 4
by
VrindaVan »
17 Sep 2023, 04:01
Hey y’all,
I just noticed that the front mounting bolt for my solex 34 pict 4 carburettor was loose as I could even wiggle it with my hand alittle,...
4 Replies
465 Views
Last post by VrindaVan
18 Sep 2023, 12:06
Lost nut
Replies: 6
by
Raynsford5 »
14 Sep 2023, 07:54
Hi all please help needed, this week I decided to renew the pushrod seals on our T3, which appears to be a 1700 T2 engine anyway while removing the...
6 Replies
463 Views
Last post by Raynsford5
17 Sep 2023, 15:44
Brakes jammed on then released
Replies: 3
by
jacko1967 »
17 Sep 2023, 07:47
Morning all
a bit of a strange one yesterday I had been driving for 2 hrs and I came to some traffic lights there was a bit of a thump and the...
3 Replies
372 Views
Last post by Robsey
17 Sep 2023, 10:44
84 1.6D stripped head for injector
Replies: 20
by
Paul773car »
08 Sep 2023, 12:06
Afternoon all, im having a very bad day.
I few weeks back i noticed i was getting blow by past one of my injectors. I ordered a new seal and the...
20 Replies
1207 Views
Last post by davidoft1
16 Sep 2023, 07:42
Forum permissions
You cannot post new topics in this forum You cannot reply to topics in this forum You cannot edit your posts in this forum You cannot delete your posts in this forum You cannot post attachments in this forum